eChapters

The Laboratory Worker is Surrounded by Many Dangers such as from..........

Handling of infectious materials.

Handling of broken glassware.

Accidental spill of corrosive reagents.

Swallowing of corrosive reagents such as concentrated Sulphuric acid,

Hydrochloric acid, sodium hydroxide, trichloroacetic acid etc.

Swallowing of infectious specimen.

Inhalation of poisonous fumes.

Infection in the conduct of necropsies.

Potential hazards in the form of inflammable chemicals and gas leakages.

Due to increase in population, rapid urbanization, industrialization and shrinking land holdings, there is tremendous pressure on availability of land resources for agriculture, which results in decreased arable land area year after year. The huge gap between present production and future requirements necessitates intensive vegetable production and availability at affordable prices. Vegetable production can be enhanced either by increasing productivity, use of improved cultivars and ago-techniques, bringing additional land under vegetable crops or by promotion of protected cultivation. By adopting protected cultivation, year round availability of quality produces both for domestic use and export can be assured.

Several biotic and abiotic stresses are the major factors responsible for low productivity and poor quality in large number of vegetable crops under open field cultivation more specifically during rainy and post rainy season. The increasing demand of off-season and high quality vegetables in various markets of the big cities had call the attention of the vegetable growers for diversification from traditional ways of vegetable cultivation to modern methods of vegetables cultivation in an agri-business entrepreneurial models. Under the new era of FDI (Foreign Direct Investment) in retail these kinds of models are having high potential for betterment of the farmers opting for quality and offseason vegetable cultivation through protected cultivation. Protected cultivation structures are useful for combating both biotic and abiotic stresses that limits the productivity and quality of vegetable crops. This requires careful planning, attention and details about timing of production and moreover, harvest time to coincide with high market prices, choice of varieties adopted to the off season environments, and able to produce economical yields of high quality produce etc.

Introduction

Organic farming per se is not a new concept rather is an age old practice of cultivation crops without synthetics. However, in modern usage it is a type of farming without synthetics but at the same time taking advantage of all the modern agriculture technologies like soil testing, nutrient management, ecofriendly pest management, etc. developing and developed world have different incentives for taking up organic farming. Growing health consciousness among the people of developed world is the prime motive behind interest in organic farming. However, conversion of “by default” organic agriculture into “certified organic” is perspective in the developing world so that farmers get price premium. Whatever the case may be, the area under organic farming as well as demand for organic food/product is increasing both in developing as well as in the developed world.

Organic production is a systems approach. Although many aspects of vegetable production remain the same in both “organic” and “non-organic” or “conventional” systems, there are differences. The major components of production which differ between these two systems include transplant production, soil fertility management, and insect, disease, and weed management. “Organic” usually refers to a crop management system that promotes biodiversity, biological cycles, and soil biological activity. Organic production concentrates on natural processes and how to manage them. Other materials and products are additions to, not replacements for, management. An organic system takes time to develop. It may be achieved in stages, for example by starting with organic soil amendments and other soil improving procedures. Then, try biological control of pests, some companion plants, etc. Eventually, the entire system will be changed. It will take years to convert to a healthy organic system.

A successful vegetable production industry is very dependent on a sustainable supply of seeds to the growers. At the present time, the seed industry plays an important role in both production and distribution of high quality vegetable seeds.

Successful seed production of a crop depends on a thorough knowledge of the reproductive process of a particular crop. The techniques of seed production must take into account several features of reproduction: whether it is sexual, asexual, or a combination of the both, the nature of floral structures, the amount of pollen transfer, the degree and means of self-incompatibility and the effect of inbreeding on vigour. For most purposes the important consideration to the seed producers is the extent of cross-pollination. It is, therefore, necessary that before engaging himself in seed production, a producer must acquaint himself with the following details of reproduction in the particular crop:

Methods of Reproduction

The method of reproduction in vegetable crop plants may be broadly grouped in to two categories, asexual/vegetative and sexual:

Improved Varieties of Tuber Vegetables

A. POTATO

Improved Varieties of Asparagus

(1) Perfection

Source : Developed at IARI, New Delhi

Maturity : Early

Spears : Large, green, succulent, heavy cropper and uniform in maturity

Production Technology of Asparagus

Climate

Asparagus is temperate season vegetable and bears excellent crop between a temperature range of 15-24ºC for most of the growing season. The ideal day temperature is 25-30^oC and night temperature 15-20^oC. It can tolerate frost up to some extent but continuous freezing is harmful for its growth. Spear initiation occurs at soil temperature of more than 10ºC. Spear elongation is faster at high air temperature. Root and shoot development is reduced below 13ºC and above 29ºC. Due to warm weather, spear tips open prematurely and quality of spears is reduced. Elevation of more than 1000m is good for high yield.

Improved Varieties of Leafy Vegetables

A. AMARANTHUS

Improved Varieties of Root Crops

A. RADISH

A. Asiatic/Tropical Varieties

Improved Varieties of Bulb Crops

A. ONION

Improved Varieties of Peas and Beans

A. VEGETABLE PEA

A. Early Varieties

Improved Varieties of Cucurbits

A. CUCUMBER, MELONS, PUMPKIN AND SQUASHES

Cucumber (Khira)

Improved Varieties of Cole Crops

A. CAULIFLOWER

Improved Varieties of OKRA (Bhindi)

Vegetable research in India is of very recent origin. Research on vegetable crops was started by ICAR with the sanctioning of a nucleus ‘Plant Introduction Scheme’ at IARI, New Delhi in 1947-48. Simultaneously, the ICAR also started such ad-hoc schemes in different states like Punjab, Uttar Pradesh, West Bengal, Maharashtra, Himachal Pradesh, Jammu & Kashmir and Tamil Nadu.

Prior to World War II, entire seeds of temperate vegetables were imported from European countries. When, during World War II, supply of vegetable seeds from Europe suffered a serious setback, the government of India felt the need for production of these seeds within the country. As a result of this, the government of India established a Vegetable Breeding Station at Katrain in Kullu Valley, Himachal Pradesh in 1949. This station was transferred to Indian Agriculture Research Institute in 1955 to undertake research on improvement of temperate vegetable crops, standardization of their seed production technology and to produce seeds of identified improved varieties of temperate vegetables. This research station is carrying out intensive research on all aspects of temperate vegetables including improvement, production technology and their seed production.

Further, a division of Horticulture was created at the Indian Agriculture Research Institute, New Delhi in 1956-57. However, vegetable research was organized on sound footing with the establishment of the Indian Institute of Horticulture Research (IIHR) at Bangalore with a full fledged Division of Vegetable Crops in 1968. The vegetable research in India received a further boost when a separate division of Vegetables Crops and Floriculture was started at IARI, New Delhi in 1970. The floriculture work was separated from the division of Vegetable Crop and Floriculture, IARI, New Delhi in 1982 and the division was then named as Division of Vegetable Crops, which was assigned the research work exclusively on different vegetable crops. In the Sixth Five-year Plan, IIHR, Bangalore started two Central Horticulture Experiment Stations, one each at Ranchi, (Bihar) and Godhra (Gujarat) to intensify research on horticultural crops in important tribal areas of the country where research on vegetable crops was also started to meet the specific requirements of these regions. Establishment of Agricultural Universities and All India Coordinated Vegetables Improvement Project gave further fillip to vegetable research in India.

Significant achievements have been made in the food availability throughout the world over the last few decades. The estimated number of people in developing regions suffering from chronic malnutrition has declined (from 946 million people in 1969-71 to 870 million people in 2010-12), as the proportion of malnourished people from 36 percent to 20 percent, even though the world population has increased. Global food supplies (if distributed according to individual requirements) are sufficient to fulfill the energy needs. An estimated 20 percent of the people in developing world are chronically under nourished, consuming too little food to meet even the minimal energy needs. Approximately 192 million children under the age of five years suffer from acute or chronic protein energy malnutrition. According to WHO, 6.9 million children under the age of five died in 2011, from direct or indirect result of hunger and malnutrition. Moreover, more than 2 billion people, mostly women and children are deficient in one or more micronutrients, babies continue to be born mentally retarded as a result of iodine deficiency, children go blind from vitamin-A deficiency and enormous number of women and children are adversely affected by iron deficiency.

The overall growth in food availability resulting from the green revolution over the last two decades has eliminated the threat of famine for India’s entire population. Country’s production of food grains has reached over 257.07 million tonnes. However, malnutrition is still a serious problem in this region. Evidences suggest that micronutrient deficiency is far more prevalent in the area than protein energy malnutrition. The International Food Policy Research Institute has reported a rising trend in micronutrient deficiencies, which is becoming more serious than malnutrition from lack of major nutrients. Thus, the emphasis is now shifting from supply of basic food (calories & protein) towards supply of balanced diet (calories, protein & micronutrients which includes vitamins and minerals).

Vegetables occupy an important place in diversification of agriculture and have played a pivotal role in the food and nutritional security of every growing population of our country. Vegetables are becoming important as cash crops for urban and export markets. Looking at the national scenario, vegetables have tremendous strength in terms of natural and genetic resources. A large number of wild taxa and indigenous germplasm are available in the country and many of them have not being fully capitalized. Though efforts have been made to tap the variability present among the vegetable crops in the country and many varieties have been released, it needs further attention so that the problems of biotic and abiotic stresses can also be minimized. The vast diversity of land, soil and agro climatic conditions prevalent in India also offers a unique competitiveness to grow wide range of vegetables. During the last four decades, India has made commendable progress in vegetable production (from 23.45 million tonnes in 1961-65 to 166.47 million tonnes in 2015-16), securing the position of second largest production of vegetables in world next only to China. The total world vegetable production is 1159.88 million tonnes from an area of 59.16 million hectares. In this, India contributes about 15.88 % with the production equal to 166.47 million tonnes from an area of 9.29 million hectares (NHB, 2015-16).

1. Potato

Scientific name: Solanum tuberosum L.

Family: Solanaceae

Origin: South America

Chromosome No.: 2n = 4x = 48

Introduction

Potato is one of the four major food crops of the world and is also a very popular vegetable crop. It is extensively cultivated in China, Russian Federation, Ukarine, Poland, Ireland, Great Britain, Germany, Netherlands, France, Spain, South America, India and USA. Potato was brought from Peru to Spain by the Spaniards in 1565 when it was widely grown in Spain and Italy. They were probably brought to England about 1586 by Sir Francis Drake. Potato was introduced in India in early 17^th century probably by the Portuguese. Now it is one of the principal cash crops of India.

Importance and use

• Potato is the fourth major food crops of the world after rice, wheat and maize.
• Being a major source of carbohydrate it is often used as a substitute for cereals.
• It is one of the major vegetable crops of the world and is grown in almost every country.
• In India, it is considered as a staple vegetable and used either alone or mixed with other vegetables.
• Potato is used as vegetable in various forms such as, boiled, mashed, baked, fried and cooked in sambar and different curries of vegetable, fish and meat.
• Potato is processed into different commercially used dehydrated, canned and fried products like, shredded potato, sliced potato, chips, flakes, French fries, finger chips, granules, disc, cubes, flour, etc.
• It is used for several industrial purposes such as production of starch, alcohol, dextrin, glucose, etc.
• Potato starch is a large grained starch and contains 25 % amylase and 73 % amylopectin and high phosphate content.

1. Seedling management in the nursery

Seedlings of many seed propagated vegetable crops like, tomato, brinjal, chillies, sweet pepper, cauliflower, cabbage, knolkhol, broccoli, Brussels sprout, kale, endive, chicory, celery, lettuce, parsley, onion, etc. are first raised in the nursery beds before transplanted in the main field although, many of these crops like, tomato, sweet pepper, onion, cabbage, cauliflower, broccoli, etc. are also direct seeded using precision seed drills in the USA, Japan, the Netherlands, Italy and other European countries. Many seed propagated vegetable crops viz., okra, peas, beans, radish, carrot, beet, turnip and all the cucurbits (e.g. bitter gourd, bottle gourd, pumpkin, cucumber, watermelon, muskmelon, snake gourd, sponge gourd, ridge gourd, etc.) are conventionally grown through direct seeding in the main field.

Transplant groups

1. Plants easy to transplant: They form new roots rapidly, put forth shoots rather slowly and absorb water readily e.g. beet, broccoli, Brussels sprouts, cabbage, cauliflower, Swiss chard, lettuce and tomato.

2. Plants transplanted with moderate ease: This group replace roots and grow shoots a bit slower than the previous group and do not absorb water very efficiently e.g. celery, brinjal, onion, pepper, leek and cauliflower.

Introduction

The book has been framed as a text book cum vegetable production manual for both under graduate and post graduate students of Agriculture/ Horticulture as well as commercial vegetable production professionals. This book has been oriented on different management practices of vegetable culture in open field condition viz., Classification of vegetable crops, Management of seedlings in the nursery, Water managent, Plant nutrient management, Pollination management, Integrated pest management, Biological management of diseases, Weed management and Production technology of different vegetable crops.

Classification of vegetable crops

Vegetables are defined as herbaceous plant origin material with generally low calorific value providing micronutrients, vitamins, antioxidants, fibre and induce alkaline reaction inside human body. Vegetable crops are not only botanically different but also their cultural and climatic adaptation shows wide variability. It is, therefore, necessary to classify the vegetable crops for their easy recognition. Vegetable crops can conveniently be classified “Botanically” for the purpose of vegetable breeding and according to “Method of culture” from the point of crop husbandry.

Botanical classification

The crops used for vegetable purpose in the world belong to 1200 species under 78 families and of them, more than 860 species under 59 families belong to dicotyledoneae and about 340 species under 19 families belong to monocotyledoneae. In the tropical and subtropical parts of the world, about 90 species of vegetable crops are cultivated, but hardly 20 of them are commercially important.

In the present botanical classification, over 140 different vegetable crops under 6 monocotyledoneae and 20 dicotyledoneae families have been included.